Loading design…
MunyratanakBrorn
Bachelor of Technology Thesis Project 2024.
| Reference | Value | Description |
|---|---|---|
| Q1 | C62892 | 0.1A Ic, 50V Vce, Dual NPN Input Resistor Transistors, SOT-363 |
| Q2,Q3 | BT136-600 | |
| Q4-Q13,Q16 | Q_NPN_BEC | NPN transistor, base/emitter/collector |
| Q14 | BSC026N08NS5 | 100A Id, 80V Vds, OptiMOS N-Channel Power MOSFET, 2.6mOhm Ron, Qg (typ) 74.0nC, PG-TDSON-8 |
| Q17 | Q_PNP_BEC | PNP transistor, base/emitter/collector |
| U1 | ESP32-WROOM-32UE |
| U2 | LAN8720A |
|---|
| U3,U8 | MCT2E | Optoisolator Transistor with Base Output 5300Vrms 1 Channel 6-DIP |
|---|
| U4,U12 | USBLC6 |
|---|
| U5 | STM32F405RGTx | STMicroelectronics Arm Cortex-M4 MCU, 1024KB flash, 192KB RAM, 168 MHz, 1.8-3.6V, 51 GPIO, LQFP64 |
|---|
| U6 | CH330N | USB serial converter, UART, SOIC-8 |
|---|
| U7,U9 | MOC3021M |
|---|
| U10 | BL0910 |
|---|
| U11 | AP130-33Y |
|---|
| U13 | MAX485E | Half duplex RS-485/RS-422, 2.5 Mbps, ±15kV electro-static discharge (ESD) protection, no slew-rate, no low-power shutdown, with receiver/driver enable, 32 receiver drive capability, DIP-8 and SOIC-8 |
|---|
| U15-U19,U27 | C3015389 | DC Optocoupler, Vce 35V, CTR 50%, SO-4 |
|---|
| U20 | XL1509-3.3 | Buck DC/DC Converter, 2A, 3.3V Output Voltage, 4.5-40V Input Voltage |
|---|
| U21 | AT24CS32-SSHM |
|---|
| U22 | C9868 |
|---|
| U23 | XL1509-5.0 | Buck DC/DC Converter, 2A, 5V Output Voltage, 7-40V Input Voltage |
|---|
| U28 | CP2102N | USB to UART master bridge, QFN-28 |
|---|
| U29-U33 | SN74LVC1G14DBV | Single Schmitt NOT Gate, Low-Voltage CMOS, SOT-23 |
|---|
| BOOT1 | SW_DPDT_x2 | Switch, dual pole double throw, separate symbols |
|---|
| BT2 | BC501SM |
|---|
| C1,C82,C83 | 2.2uF |
|---|
| C2,C7,C10,C11,C21,C22,C57,C58 | 100nF | Unpolarized capacitor |
|---|
| C3,C12,C14 | 1uF |
|---|
| C4,C5,C9 | 22uF |
|---|
| C6 | NC |
|---|
| C13 | 470pF |
|---|
| C15 | 30pF |
|---|
| C16-C18,C44,C45,C49,C53-C56,C60,C61 | 100n |
|---|
| C19,C20,C23,C24,C26-C43,C50-C52 | 33nF | Unpolarized capacitor |
|---|
| C25 | 10uF/10V | Unpolarized capacitor |
|---|
| C46,C47 | 20pF |
|---|
| C48 | 1u |
|---|
| C59,C69 | 220uF/16V | Polarized capacitor |
|---|
| C62,C63 | 220uF/35V | Polarized capacitor |
|---|
| C64,C65,C68,C70 | C | Unpolarized capacitor |
|---|
| C71 | 1000uF | Unpolarized capacitor |
|---|
| D1,D3-D5 | ESD9B3.3ST5G |
|---|
| D2,D7,D9,D33-D37 | LED | Light emitting diode |
|---|
| D6,D32 | D_Schottky |
|---|
| D8 | MBS6 | 0.8A, 600V, Standard Bridge Rectifier |
|---|
| D10-D31 | 1N4148WS | 75V 0.15A Fast switching Diode, SOD-323 |
|---|
| D38,D45-D54 | D | Diode |
|---|
| D39,D40,D42 | SS34 | 40V 3A Schottky Diode, SMA |
|---|
| D41 | SZNUP2105L | Dual Line CAN Bus Protector, 24Vrwm, Automotive Grade |
|---|
| D55 | LED_RX | Light emitting diode |
|---|
| D56 | LED_TX | Light emitting diode |
|---|
| DRA1,DRA2 | DIN_Rail_Adapter | DIN Rail adapter universal, mounting holes without connection |
|---|
| F1,F3 | 0.1A | Fuse, small symbol |
|---|
| F2 | Fuse | Fuse |
|---|
| FB1 | C139168 |
|---|
| FB2,FB4 | FB_Small |
|---|
| FB3 | Ferrite_Bead_Small |
|---|
| H1-H4 | MountingHole_Pad |
|---|
| HS1,HS2 | Heatsink_Pad |
|---|
| HSE1 | 8MHz |
|---|
| J1 | Screw_Terminal_01x06 | Generic screw terminal, single row, 01x06, script generated (kicad-library-utils/schlib/autogen/connector/) |
|---|
| J2,J5,J6,J11 | Screw_Terminal_01x04 |
|---|
| J3 | USB_C_Receptacle_USB2.0_16P | USB 2.0-only 16P Type-C Receptacle connector |
|---|
| J4 | HR911105A | DIP RJ45 Connector; |
|---|
| J7 | DE9_Plug_MountingHoles | 9-pin male plug pin D-SUB connector, Mounting Hole |
|---|
| J8-J10,J12,J14,J16-J18,J22-J26,J29-J32,J36 | Conn_01x02_Pin | Generic connector, single row, 01x02, script generated |
|---|
| J13,J27 | 0533980671 |
|---|
| J15,J20 | Conn_01x04_Pin | Generic connector, single row, 01x04, script generated |
|---|
| J19 | C7506797 | USB 2.0-only 16P Type-C Receptacle connector |
|---|
| J21 | AC INPUT | Generic screw terminal, single row, 01x02, script generated (kicad-library-utils/schlib/autogen/connector/) |
|---|
| J28 | SM04B-ZESS-TB_LF__SN_ |
|---|
| J33-J35 | Screw_Terminal_01x02 | Generic screw terminal, single row, 01x02, script generated (kicad-library-utils/schlib/autogen/connector/) |
|---|
| K1-K5 | Relay_SPST-NO | Relay SPST, Normally Open, EN50005 |
|---|
| L1 | L | Inductor |
|---|
| L2,L4 | C3224219 |
|---|
| LED1,LED2 | R |
|---|
| LED3 | Y |
|---|
| LED4 | B |
|---|
| P1 | C7529389 | Micro SD Card Socket |
|---|
| PS1 | HLK-12M05A | Compact AC/DC board mount power module 12W 5V |
|---|
| R1,R89,R99,R101,R103,R105,R107,R109,R111,R113,R115,R117,R119 | 100K | Resistor, small symbol |
|---|
| R2,R3,R8-R10,R13,R14,R32,R37,R90,R121,R122,R125,R139,R140 | 10K | Resistor |
|---|
| R4-R7,R28,R29 | 22R |
|---|
| R11,R98,R100,R102,R104,R106,R108,R110,R112,R114,R116,R118,R123,R124 | 4.7K | Resistor,Resistor, small symbol |
|---|
| R12,R15,R22,R83,R131 | 0R | Resistor |
|---|
| R16 | 12.1K |
|---|
| R17,R18,R20,R21 | 49.9R |
|---|
| R19,R97 | 220K | Resistor |
|---|
| R23,R30 | 47K |
|---|
| R24,R25,R31,R35,R36,R92-R94 | 1K |
|---|
| R26,R27,R81,R82,R137,R138 | 5.1K |
|---|
| R33,R34,R38,R39,R129,R132,R133 | 330 |
|---|
| R40-R45 | 22K | Resistor |
|---|
| R46,R49 | 220R | Resistor |
|---|
| R47,R48,R60-R77,R79,R80,R84-R88 | 510R | Resistor |
|---|
| R50 | 2K | Resistor |
|---|
| R51-R59,R78 | 30R | Resistor |
|---|
| R91,R95,R96 | 100R | Resistor, small symbol |
|---|
| R120 | 20K | Resistor |
|---|
| R126 | DNP | Resistor |
|---|
| R128,R130 | 10R | Resistor |
|---|
| R134 | 100 |
|---|
| SW1,SW2 | C221895 | Tactile Switch SPST-NO Top Actuated Surface Mount |
|---|
| T1 | HPT225A-G | Transformer, single primary, single secondary |
|---|
| TP1-TP10 | TestPoint_Probe | test point (alternative probe-style design) |
|---|
| TP11-TP15,TP18,TP19 | C5199900 | test point (alternative probe-style design) |
|---|
| TP16,TP17 | TestPoint | test point |
|---|
| Y3 | 32768Hz |
|---|